Crown

Board: Porsche - Cayenne Language: English Region: Worldwide Share/Save/Bookmark Close

Forum - Thread

    Sep 2, 2006 5:24:55 AM

    Max (SD)
    Newbie
    Max (SD)
    Loc: San Diego
    Posts: 28, Gallery
    Registered on: Jun 20, 2003

    Cayenne S, Drive Shaft Bushing failure

    Just brought my wifes Cayenne S to the dealer as it was vibrating at anything above 4,000 rpm. I will pick her up tomorrow after I pay $1300 for replacing the drive shaft which had a failed bushing. Apparently it is a sealed system and an entire section or in fact the whole drive shaft needed to be replaced. I will know more tomorrow. Any one experience the same? Car is an 2004, with 64k miles.

    Sep 2, 2006 8:47:19 AM

    Matt C
    Veteran
    Matt C
    Loc: Switzerland , Switzerland
    Posts: 1092, Gallery
    Registered on: Apr 28, 2003
    Reply to: Max (SD)

    Re: Cayenne S, Drive Shaft Bushing failure

    Wasn't there a TSB about the drive shaft?

    Mine had to be replaced under warrarnty about 2 years ago just 6 month into ownership.

    Sep 2, 2006 11:25:59 AM

    GM AustinM
    Rennteam Moderator
    GM Austin
    Loc: Texas , United States
    Posts: 3530, Gallery
    Registered on: Sep 10, 2002
    Reply to: Matt C

    Re: Cayenne S, Drive Shaft Bushing failure

    Everybody says there's a TSB about the cardan shaft but I can't find it. Maybe it was a recall? In any event, yes, the cardan shaft vibration is a very well documented Cayenne issue. Mine was never replaced but I know many were, and they were replaced under warranty.

    Sep 2, 2006 8:49:54 PM

    Max (SD)
    Newbie
    Max (SD)
    Loc: San Diego
    Posts: 28, Gallery
    Registered on: Jun 20, 2003
    Reply to: GM AustinM

    Re: Cayenne S, Drive Shaft Bushing failure

    If there was a TSB, then mine should have been replaced under warranty irrespective if my car was out of warranty? Where can I find more info regarding TSB's?

    Sep 2, 2006 9:26:55 PM

    GM AustinM
    Rennteam Moderator
    GM Austin
    Loc: Texas , United States
    Posts: 3530, Gallery
    Registered on: Sep 10, 2002
    Reply to: Max (SD)

    Re: Cayenne S, Drive Shaft Bushing failure

    For a small donation you can view all Porsche TSB's at RennTech.org

    Sep 3, 2006 6:58:40 AM

    Matt C
    Veteran
    Matt C
    Loc: Switzerland , Switzerland
    Posts: 1092, Gallery
    Registered on: Apr 28, 2003
    Reply to: GM AustinM

    Re: Cayenne S, Drive Shaft Bushing failure

    The TSB is 4822 4 1/2004 - "Rattling noise in the area of the steering shaft and driver's footwell" and it is still available at RennTech.org!

    Sep 3, 2006 12:42:06 PM

    GM AustinM
    Rennteam Moderator
    GM Austin
    Loc: Texas , United States
    Posts: 3530, Gallery
    Registered on: Sep 10, 2002
    Reply to: Matt C

    Re: Cayenne S, Drive Shaft Bushing failure

    Quote:
    Matt C said:
    The TSB is 4822 4 1/2004 - "Rattling noise in the area of the steering shaft and driver's footwell" and it is still available at RennTech.org!



    Thanks Matt, but I think that is the steering shaft replacement, not the cardan shaft (driveshaft).

    Sep 4, 2006 4:47:46 AM

    Matt C
    Veteran
    Matt C
    Loc: Switzerland , Switzerland
    Posts: 1092, Gallery
    Registered on: Apr 28, 2003
    Reply to: GM AustinM

    Re: Cayenne S, Drive Shaft Bushing failure

    Uups, sorry Gary.

    Nevertheless, I checked my records and they replaced the cardan shaft back then.

    Sep 7, 2006 10:48:15 PM

    Mick
    Pilot
    Mick
    Loc: SouthEastern PA, USA
    Posts: 363, Gallery
    Registered on: Jun 30, 2003
    Reply to: Matt C

    Re: Cayenne S, Drive Shaft Bushing failure

    There was no TSB for the shaft it was a service action based on VIN. All 03's and early 04's were effected. Bad 03 part numbers got into 04's due to shortages. The part number changes but I cannot find the numbers sorry

    Sep 8, 2006 8:40:47 PM

    GM AustinM
    Rennteam Moderator
    GM Austin
    Loc: Texas , United States
    Posts: 3530, Gallery
    Registered on: Sep 10, 2002
    Reply to: Mick

    Re: Cayenne S, Drive Shaft Bushing failure

    Thanks Mike!

    Apr 23, 2007 6:48:37 PM

    Dirtguy
    Newbie
    Dirtguy
    Loc: Austin, Texas
    Posts: 1, Gallery
    Registered on: Nov 28, 2004
    Reply to: GM AustinM

    Re: Cayenne S, Drive Shaft Bushing failure

    I have a 2004 Cayenne S I bought in new in Austin. I also have 64K miles on it and the center bushing on the rear drive shaft has gone out. I have 100K mile Certified Porsche warranty. The dealer in San Antonio is telling me that my problem is not covered under the warranty. Did you guys have your problems repaired under warranty?

    Apr 23, 2007 11:08:48 PM

    Mick
    Pilot
    Mick
    Loc: SouthEastern PA, USA
    Posts: 363, Gallery
    Registered on: Jun 30, 2003
    Reply to: Dirtguy

    Re: Cayenne S, Drive Shaft Bushing failure

    Yes, I only know one 1 that wasnt

    Apr 26, 2007 3:30:54 AM

    GM AustinM
    Rennteam Moderator
    GM Austin
    Loc: Texas , United States
    Posts: 3530, Gallery
    Registered on: Sep 10, 2002
    Reply to: Mick

    Re: Cayenne S, Drive Shaft Bushing failure

    Mine just went out last week. It was covered under a non-Porsche extended warranty that I purchased from the dealer. The charge was around $950 I think.

    Apr 27, 2007 12:40:58 AM

    Mick
    Pilot
    Mick
    Loc: SouthEastern PA, USA
    Posts: 363, Gallery
    Registered on: Jun 30, 2003
    Reply to: GM AustinM

    Re: Cayenne S, Drive Shaft Bushing failure

    Any rotating noise under the drivers side Gary ? not engine, not transmission possible tranfer case or Cardan.

    Apr 27, 2007 3:13:54 AM

    GM AustinM
    Rennteam Moderator
    GM Austin
    Loc: Texas , United States
    Posts: 3530, Gallery
    Registered on: Sep 10, 2002
    Reply to: Mick

    Re: Cayenne S, Drive Shaft Bushing failure

    At the time it went out there was a very loud noise under acceleration. I thought I had a flat tire at first the thumping and vibration was so bad. It was hard to pinpoint the origin at the time but seemed to come more from the rear and/or passanger side of the car, not from the drivers side area. Under no-load the vibration would go away.

    Apr 28, 2007 2:46:20 PM

    Mick
    Pilot
    Mick
    Loc: SouthEastern PA, USA
    Posts: 363, Gallery
    Registered on: Jun 30, 2003
    Reply to: GM AustinM

    Re: Cayenne S, Drive Shaft Bushing failure

    OH I guess it will fail eventually and we will find out, hahaha
     
    Edit

    Forum

    1. All 

    Boards

     
    Board Subject Last post Rating Views Replies
    Porsche Sticky SUN'S LAST RUN TO WILSON, WY - 991 C2S CAB LIFE, END OF AN ERA (Part II) 5/15/24 8:44 AM
    art.italy     		812865 1808
    Porsche Sticky Welcome to Rennteam: Cars and Coffee... (photos) 4/7/24 11:48 AM
    Boxster Coupe GTS     		452860 565
    Porsche Sticky OFFICIAL: Porsche 911 (992) GT3 RS - 2022 3/12/24 8:28 AM
    DJM48     		272949 323
    Porsche Sticky The new Macan: the first all-electric SUV from Porsche 1/30/24 9:18 AM
    RCA     		91995 45
    Porsche Sticky OFFICIAL: Taycan 2024 Facelift 3/15/24 1:23 PM
    CGX car nut     		9226 50
    Porsche The moment I've been waiting for... 2/1/24 7:01 PM
    Pilot
     
     
     
     
     
    		 891369 1364
    Porsche 992 GT3 7/23/23 7:01 PM
    Grant     		850257 3868
    Porsche GT4RS 4/21/24 11:50 AM
    mcdelaug     		404838 1454
    Porsche Welcome to the new Taycan Forum! 2/10/24 4:43 PM
    nberry     		401528 1526
    Others Tesla 2 the new thread 12/13/23 2:48 PM
    CGX car nut     		389334 2401
    Porsche Donor vehicle for Singer Vehicle Design 7/3/23 12:30 PM
    Porker     		373046 797
    Porsche Red Nipples 991.2 GT3 Touring on tour 5/12/24 6:23 PM
    blueflame     		295393 669
    Porsche Collected my 997 GTS today 10/19/23 7:06 PM
    CGX car nut
     
     
     
     
     
    		 270036 812
    Lambo Huracán EVO STO 7/30/23 6:59 PM
    mcdelaug     		245487 346
    Lotus Lotus Emira 6/25/23 2:53 PM
    Enmanuel     		239742 101
    Others Corvette C8 10/16/23 3:24 PM
    Enmanuel     		223924 488
    Others Gordon Murray - T.50 11/22/23 10:27 AM
    mcdelaug     		174448 387
    BMW M 2024 BMW M3 CS Official Now 12/29/23 9:04 AM
    RCA     		122807 303
    Motor Sp. 2023 Formula One 12/19/23 5:38 AM
    WhoopsyM     		114904 685
    Porsche 2022 992 Safari Model 3/7/24 4:22 PM
    WhoopsyM     		87020 239
    AMG Mercedes-Benz W124 500E aka Porsche typ 2758 2/23/24 10:03 PM
    blueflame     		77313 297
    Porsche 992 GT3 RS 3/3/24 7:22 PM
    WhoopsyM     		56450 314
    Motor Sp. Porsche 963 5/18/24 9:44 PM
    Wonderbar     		28180 249
    Ferrari Ferrari 296 GTB (830PS, Hybrid V6) 1/21/24 4:29 PM
    GT-Boy     		22779 103
    BMW M 2022 BMW M5 CS 4/8/24 1:43 PM
    Ferdie     		21590 140
    AMG G63 sold out 9/15/23 7:38 PM
    Nico997     		18005 120
    AMG [2022] Mercedes-AMG SL 4/23/24 1:24 PM
    RCA     		16079 225
    Porsche Porsche Mission X Hypercar 12/3/23 8:52 AM
    996FourEss     		11928 63
    Porsche 911 S/T 10/10/23 8:53 AM
    RCA     		11192 55
    Others Tesla thread N°3 5/1/24 11:09 PM
    CGX car nut     		9407 93
    113 items found, displaying 1 to 30.