Crown

Board: Porsche - 911 - 997 Language: English Region: Worldwide Share/Save/Bookmark Close

Forum - Thread


    Battery died this morning...

    Garaged the 997S last night as normal. Tried to start it this morning and got a series of flashing lights and clicking noises together with a series of warning messages.

    Rang Porsche assistance. They sent a guy with jump leads who managed to start it, but it wouldn't hold the charge. So low-loader to OPC it was... Courtesy car arrived this afternoon - Merc S Class - very nice if you want to be chauffeured .

    Why is it there's no warning that a battery is going to fail? It was turning over fine yesterday and dead today.

    One thing I have noticed over the past few weeks is that I get an occassional beep from the horn for no apparent reason - usually when I've opened the door or after locking it? Enough to think a bit strange but not overly concerning - until now maybe??

    Do you think the car was trying to warn me in some way? You know - looking after it's mate...

    The OPC have confirmed the battery is dead! That must have been difficult for them. Now they are keeping it to investigate the voltage loss.

    You guys got any ideas...

    Re: Battery died this morning...

    This happened to mine and the recovery chap said it was pretty common for the battery to fail after a couple of years. When I said that they lasted a lot longer in the old days, he said that in the old days they didn't have to worry about trackers, alarms, sat navs etc. I suppose he's right, but you'd think they would make better batteries to cope with it all.

    What made mine particularly nerve wracking was that I was parked in a dodgy underground car park and the recovery truck couldn't get to the car to tow it out.

    Re: Battery died this morning...

    Quote:
    John H said:
    One thing I have noticed over the past few weeks is that I get an occassional beep from the horn for no apparent reason - usually when I've opened the door or after locking it?



    In my experience, that beep on remotely locking the door usually means that you've left the trunk-lid or center-console bin lid open, or one of the car doors isn't correctly closed.

    Re: Battery died this morning...

    I'd say the PCM is the problem from my experience. My battery was ruined and replaced because of it. PCM was defective and was eventually replaced.

    Normal current draw is shown below. When you get car back "fixed" have them show you this with a meter before you drive away.

    Make sure you are convinced of your draw rate. My suspicion was my car was never fixed, I just kept it on a battery maintainer "all" the time to be safe.

    Re: Battery died this morning...

    I suspect the battery incurred some kind of damage as you were driving. An internal part (e.g., one of the buss bars) probably cracked. It could have been a manufacturing defect or just metal fatigue due to vibration. Of course, there's no way to verify this without breaking open the battery. Yet its failure was so sudden that it must have involved some kind of internal mechanical damage rather than just sulfating up.

    Re: Battery died this morning...

    Quote:
    fritz said:
    In my experience, that beep on remotely locking the door usually means that you've left the trunk-lid or center-console bin lid open, or one of the car doors isn't correctly closed.



    Center console lid doesn't give a honk. There is the socket for e.g. the battery maintainer in there and you need to keep the lid open to use it. But open glove box might give a honk, too.

    Quote:
    John H said:
    One thing I have noticed over the past few weeks is that I get an occassional beep from the horn for no apparent reason - usually when I've opened the door or after locking it?



    In general, if the car gives a honk it indicates that locking failed partially or completely. That is why it honks again when you are trying to open it. It was never locked and tries to lock again. If it wasn't locked the car's control units were not powered down and drained the battery.
    If you frequently get a honk although the doors and lids are closed there might be a problem with one of the door locks or the locking mechanism of the lids.

    Re: Battery died this morning...

    Quote:
    Ed J said:
    This happened to mine and the recovery chap said it was pretty common for the battery to fail after a couple of years. When I said that they lasted a lot longer in the old days, he said that in the old days they didn't have to worry about trackers, alarms, sat navs etc. I suppose he's right, but you'd think they would make better batteries to cope with it all.

    What made mine particularly nerve wracking was that I was parked in a dodgy underground car park and the recovery truck couldn't get to the car to tow it out.



    Towing a car to install a battery. I love that. A guy on a scooter could deliver and install a battery in 5 minutes. I can see just abonding the car in the garage because it coulde not be towed out to get the battery.

    On a related note - I am one of the rare owners to get a warranty battery replacement after 3.5 years and 40K miles of constant use. If the car is not driven frequently you must attach a battery maintainer because of all the electronics constantly draining the battery - which kills batteries quickly. In my case I was able to prove that I drove the minimum number of miles required (by far) and the battery had just been exhausted.
    Radar detectors, cell phone chargers etc. are also a problem since most of the outlets are constantly hot rather than switched with the ignition - They should change that.
    A beep from the horn when you lock the car usually means that one of the doors is not closed, including the hoods, glovebox, center console etc. - if all those are closed and it persists then disconnect the negative battery terminal cable for 10 seconds and reconnect. If you still hear a beep when you lock the car you may have a failing battery (or any number of electronic failures).

    Re: Battery died this morning...

    I heard Porsche uses Gel batteries and these, while safer, don't have the lifespan of the lead/acid plate kind.

    Re: Battery died this morning...

    Quote:
    Heist said:
    I heard Porsche uses Gel batteries and these, while safer, don't have the lifespan of the lead/acid plate kind.



    I had three new Porsches since 2003 and they all were conventional "wet" lead/acid batteries.


    Re: Battery died this morning...

    Got the car back today.

    To answer a few comments:-

    The invoice showed - Battery (80AH)- Pounds121.85 and Battery Acid - Pounds12.86. (so no Gel then!) Apparently 80AH is the largest capacity battery available.

    They ran tests to discover the reason for the horn beeping without success. As soon as I got it home and opened the door it beeped at me again...

    After some thought, I'm pretty sure this beeping started when I had a faulty key replaced but I'm not 100% sure.

    So I'm going to use my spare for a while just to see....

    The massive up-side is that the car is so much livelier - just wish I'd replaced the ailing battery earlier. It now turns over so much quicker, I should have noticed the problem arising. I'll replace it promptly next time it slows down.

    Pounds130 is small change for peace of mind.

    Re: Battery died this morning...

    I'd get to the auto supply store and buy a hydrometer and check the charge level of battery over the next few days/weeks.

    What did they claimn to have fixed? Did you get any proof that the current draw was within spec?

    BTW: be extremely careful with drawing out the acid: can perm. cripple your eyes.

    Re: Battery died this morning...

    The explanation given was that my battery had dropped a cell and wouldn't hold a charge - therefore it was useless!

    My alternator was fine and the new battery was tested for loss of voltage. That was the 'fix'.

    With respect, I won't be risking my eyesight but many thanks for your input.

    Re: Battery died this morning...

    Quote:
    John H said:
    The explanation given was that my battery had dropped a cell and wouldn't hold a charge - therefore it was useless!

    My alternator was fine and the new battery was tested for loss of voltage. That was the 'fix'.

    With respect, I won't be risking my eyesight but many thanks for your input.



    I _believe_ when cells short out ("drops a cell"(?)) it's because the battery was deeply discharged and insoluble sulfation occurs bridging the gap between plates in one or more cells.

    IOW, the battery was damaged by some problem in the car that caused deep discharge.

    FWIW, you may still have a problem that's causing battery to be discharged. Just something to keep in mind; I'm no expert by anymeans.

    Good luck John.


    Re: Battery died this morning...

    Quote:
    MMD said:
    Quote:
    John H said:
    The explanation given was that my battery had dropped a cell and wouldn't hold a charge - therefore it was useless!

    My alternator was fine and the new battery was tested for loss of voltage. That was the 'fix'.

    With respect, I won't be risking my eyesight but many thanks for your input.



    I _believe_ when cells short out ("drops a cell"(?)) it's because the battery was deeply discharged and insoluble sulfation occurs bridging the gap between plates in one or more cells.

    IOW, the battery was damaged by some problem in the car that caused deep discharge.

    FWIW, you may still have a problem that's causing battery to be discharged. Just something to keep in mind; I'm no expert by anymeans.

    Good luck John.





    Thank you MMD .

    I'll certainly be keeping a close watch on anything that could cause an apparent drop in battery performance. Particularly the horn beeping symptom which the OPC couldn't fathom. So far the change of key seems to have stopped it... but it's early days.

    I did quiz them about a possible 'problem' which could have killed the battery on the premise that, if there was one, I could have claimed the whole cost on warranty.

    They reckon not - but we'll see.... I'm very grateful for your time and help.

    Re: Battery died this morning...

    Quote:
    John H said:


    They reckon not - but we'll see.... I'm very grateful for your time and help.



    It's my pleasure to be helpful. Got my fingers crossed yours is _fixed_. If not, hopefully you might avoid extra time spent getting yours sorted.

    When I had problems (mentioned above) it took me three (maybe four!?) long trips to dealer as they slowly figured out what was wrong: not kidding. Was summer so drive was kinda fun BUT still a PITA.

    Re: Battery died this morning...

    Quote:
    ewi said:
    Quote:
    fritz said:
    In my experience, that beep on remotely locking the door usually means that you've left the trunk-lid or center-console bin lid open, or one of the car doors isn't correctly closed.



    Center console lid doesn't give a honk. There is the socket for e.g. the battery maintainer in there and you need to keep the lid open to use it. But open glove box might give a honk, too.




    You're right.
    I was thinking back to my 996, whose center console lid had a lock and was covered by the alarm. That car used to talk to me often if I didn't shut the lid fully after using the garage door remote control. Was one of the reasons I got the Home Link on my 997.

    Re: Battery died this morning...

    Update.... car hasn't honked since using the spare key.

    MMD - I'm hoping against hope that I don't have a PCM problem as it's not covered by my extended warranty.

    Re: Battery died this morning...

    Quote:
    John H said:
    Update.... car hasn't honked since using the spare key.

    MMD - I'm hoping against hope that I don't have a PCM problem as it's not covered by my extended warranty.



    Awwwwwwww..., sh*************t. Not sure if I should tell you but mine would have cost us$2500.00. Sorry to hear and tell you.

    Re: Battery died this morning...

    Quote:
    John H said:
    After some thought, I'm pretty sure this beeping started when I had a faulty key replaced but I'm not 100% sure.
    ...
    Update.... car hasn't honked since using the spare key.




    Hmm, maybe the new key was not correctly learned by the immobilizer system?
    Or another thought, did you program any comfort options like auto lock, auto unlock or seat memory with the old key? Maybe these functions were not cleared before learning the new key. Try reprogramming these options with the new key.

    BTW, do you get two honks when using the replacement key or just one?
    According to the manual, if you get two honks there is a failure in the immobilizer system.

    Re: Battery died this morning...

    EWI - Thanks for the advice. I haven't had any honks since using the spare key. I'm pretty sure the other key must be faulty...will check with OPC after the holidays.

    One thing I have noticed, since the battery/key change, is that the interior light doesn't stay on when locking/unlocking. It used to stay on for minutes or until the car was locked. Now it goes out within a second of coming on.

    Re: Battery died this morning...

    Quote:
    John H said:

    One thing I have noticed, since the battery/key change, is that the interior light doesn't stay on when locking/unlocking. It used to stay on for minutes or until the car was locked. Now it goes out within a second of coming on.



    Just a guess on my part but if you have Sport Chrono you might be able to change that to match your preference. (SC allows several pref changes).




    Re: Battery died this morning...

    Quote:
    MMD said:
    Quote:
    John H said:

    One thing I have noticed, since the battery/key change, is that the interior light doesn't stay on when locking/unlocking. It used to stay on for minutes or until the car was locked. Now it goes out within a second of coming on.



    Just a guess on my part but if you have Sport Chrono you might be able to change that to match your preference. (SC allows several pref changes).





    I don't have Sports Chrono, but thanks anyway...

    Re: Battery died this morning...

    Quote:
    John H said:


    I don't have Sports Chrono, but thanks anyway...



    Yeah..., don't worry about not having it. I think the dahs looks better w/o it.

    Looks like you have to go to dealer and get them to change things back if you miss them.

    Hey! Sounds the subject of a new thread...!


     
    Edit

    Forum

    Board Subject Last post Rating Views Replies
    Porsche Sticky SUN'S LAST RUN TO WILSON, WY - 991 C2S CAB LIFE, END OF AN ERA (Part II) 4/17/24 7:16 AM
    GnilM
    758670 1798
    Porsche Sticky Welcome to Rennteam: Cars and Coffee... (photos) 4/7/24 11:48 AM
    Boxster Coupe GTS
    433207 565
    Porsche Sticky OFFICIAL: Cayman GT4 RS (2021) 5/12/23 12:11 PM
    W8MM
    259524 288
    Porsche Sticky OFFICIAL: Porsche 911 (992) GT3 RS - 2022 3/12/24 8:28 AM
    DJM48
    256686 323
    Porsche Sticky The new Macan: the first all-electric SUV from Porsche 1/30/24 9:18 AM
    RCA
    80460 45
    Porsche Sticky OFFICIAL: Taycan 2024 Facelift 3/15/24 1:23 PM
    CGX car nut
    5300 50
    Porsche The moment I've been waiting for... 2/1/24 7:01 PM
    Pilot
     
     
     
     
     
    870269 1364
    Porsche 992 GT3 7/23/23 7:01 PM
    Grant
    805067 3868
    Porsche Welcome to the new Taycan Forum! 2/10/24 4:43 PM
    nberry
    385578 1526
    Porsche GT4RS 4/17/24 4:12 PM
    nberry
    383928 1451
    Others Tesla 2 the new thread 12/13/23 2:48 PM
    CGX car nut
    366726 2401
    Porsche Donor vehicle for Singer Vehicle Design 7/3/23 12:30 PM
    Porker
    365177 797
    Ferrari Ferrari 812 Superfast 4/21/23 8:09 AM
    the-missile
    287515 550
    Porsche Red Nipples 991.2 GT3 Touring on tour 4/11/24 12:32 PM
    Ferdie
    285295 668
    Porsche Collected my 997 GTS today 10/19/23 7:06 PM
    CGX car nut
     
     
     
     
     
    258735 812
    Lambo Huracán EVO STO 7/30/23 6:59 PM
    mcdelaug
    236539 346
    Lotus Lotus Emira 6/25/23 2:53 PM
    Enmanuel
    224474 101
    Others Corvette C8 10/16/23 3:24 PM
    Enmanuel
    219342 488
    Others Gordon Murray - T.50 11/22/23 10:27 AM
    mcdelaug
    166567 387
    Porsche Back to basics - 996 GT3 RS 6/11/23 5:13 PM
    CGX car nut
    138548 144
    BMW M 2024 BMW M3 CS Official Now 12/29/23 9:04 AM
    RCA
    115371 303
    Motor Sp. 2023 Formula One 12/19/23 5:38 AM
    WhoopsyM
    107321 685
    Others Valkyrie final design? 4/28/23 2:45 AM
    Rossi
    99227 219
    Porsche 2022 992 Safari Model 3/7/24 4:22 PM
    WhoopsyM
    83542 239
    AMG Mercedes-Benz W124 500E aka Porsche typ 2758 2/23/24 10:03 PM
    blueflame
    74878 297
    Porsche 992 GT3 RS 3/3/24 7:22 PM
    WhoopsyM
    53021 314
    Motor Sp. Porsche 963 3/16/24 9:27 PM
    WhoopsyM
    24646 237
    Ferrari Ferrari 296 GTB (830PS, Hybrid V6) 1/21/24 4:29 PM
    GT-Boy
    20919 103
    BMW M 2022 BMW M5 CS 4/8/24 1:43 PM
    Ferdie
    19188 140
    AMG G63 sold out 9/15/23 7:38 PM
    Nico997
    16447 120
    129 items found, displaying 1 to 30.